Only protection device for protection against neutral open and double phasing protection
Most of the equipments today are having power supply which can handle fluctuations between 170V to 270V. Also a lot of equipments have built in over voltage protection.
However there are accidental cases where trees fall on over head wires or accidentally neutral opens and resulting fault causes voltage in single phase to shoot upto 440V. The in built over voltage protection of any equipment is of no use , because they get damaged themselves. OVCD is protection device for protection against such problems of neutral open or double phasing.
If you look at the pictures above you can see a typical distribution line problem. There is chance of wire sagging and over head wires touching each other . this can easily cause double phasing condition.
OVCD cuts off the supply to equipment whenever there is such a problem and connects the supply only when the voltage comes back to normal.
It effortlessly withstands voltage fluctuations up to 440 Volts and spikes up to 6000 Volts. It is programmed with a power-on delay of 3 seconds (configurable) for initial surges which are harmful to any other device.
Why should you consider using OVCD before your equipment?
USP:
Now you can install your equipment in the worst electrical conditions without being bothered about service calls.
Cost to company if your product breaks down.
Man power cost | Rs 800 | Travelling and per day costof service person |
Production down time | Rs 1000 | Could cost upward dependingthe type of machine |
Part replacement | Rs 500 | Could cost upward |
Equipment decay | Yes | Reduction of life of equipment |
Goodwill lost | Yes | Incalculable |
Customer’s loss | Yes | Significant |
Disturbing to business focus | Yes | Significant( both to customersand vendor) |
Replacement of product | Product cost | Capital Loss |
All figures in Indian rupees
Costs projected are indicative and may vary for product and services
Features
OVCD is connected at before the equipment in use.
Incoming current will first pass through OVCD then into the equipment. OVCD continuously monitors the line voltage.
Whenever the voltage is above or below the set voltage limits the OVCD simply cuts the voltage to the equipment thereby saving it from the line disturbance. It reacts within fraction of second to the disturbance. OVCD will withstand the voltage even as high as 440 Volts.It however does not stabilize the voltage as in the case of other devices in the same category like Stabilizer, CVTs.
When the voltage returns to normal , the OVCD resumes the supply to the equipment with short power-on delay of 3 seconds(configurable). This feature is called the Smart Start. It prevents the initial harmful transient that may damage the Equipment.
How is OVCD better than other power conditioning / protection products?
FEATURES | OVCD | Servos | Stabilizer | CVT | Spike buster |
Protection up to 440V |
Yes |
No | No | No | No |
Under voltage / Over voltage protection | Yes | No | No | No | No |
Protection from spikes | Yes |
No | No | Yes | Yes |
Protection from over load | Yes |
No | No | Yes | No |
Line indication | Yes |
No | No | No | Yes |
EMI /RFI filters | Yes |
No | No | No | No |
Waveform distortion | No |
No | No | Yes | No |
IC technology | Yes |
No | No | Yes | No |
Customized to suit your requirements.
We can customize the OVCD in following ways.
End Use application
UPS | AC drives | Medical Equipments |
Solar power plants | Compressors | CCTV system |
Refrigeration equipments | Control Panels | Dish Satellite System |
[…] at MSS have developed , perfected and implemented device called OVCD for protection of equipments from power […]
LikeLike
[…] Susceptibility of electronic equipment to these other power disturbances is defined by other aspects of the system design, either inside the equipment itself or externally by means of a circuit which typically consists of a voltage-sensing circuit and a relay for disconnecting the AC input when the voltage reaches a danger threshold. See OVCD). […]
LikeLike
[…] Over Voltage Cut-off Device […]
LikeLike
[…] Over Voltage Cut-off Device […]
LikeLike
[…] OVCD-Over Voltage cutoff Device […]
LikeLike
[…] 3. OVCD […]
LikeLike
[…] 3. OVCD […]
LikeLike
what this price of ovcd
LikeLike
Dear sir
i used this device and this works very good and useful for all electrical work
now i want to purchase one more but unable to find out so please give me any link to find this device…………………………..excellent.
LikeLike
if u want to buy ………..please contact 9769696201
LikeLike
my name is sat pal singh bawa iam living
in distt firozpur punjab iwant to puchse 2 no. servo stablisersof 5 kva each with high and low+doublephase cut PLEASETELL FROM WHERE ICAN BUY AND ALSO THE PRICE 9914400640
LikeLike
Over voltage cut off 277 vac
Under voltage cut off 165 vac
input:230AC,50-60Hz
LikeLike
[…] OVCD- Over Voltage Cut-off Device […]
LikeLike
Is this OVCD can sense Generator power which is supplying Squave wave or Quasi-Sine wave supply ?
LikeLike
no it will not sense waveshape, however if there are any disturbances(spikes ) , it will filter out.
LikeLike
Need ovcd for electric /electronic equipments for protection from surges and other problems.
LikeLike
Please contact us on 9769996205
LikeLike
Hi,
There is a lot of power fluctuation in our area, Hence I am looking for Voltage Control Device.
Is this product available in Bengaluru ? Please give me the Address or contact number of the dealer.
Thanks,
Sandesh
LikeLike
you can buy our product online from https://www.instamojo.com/micross/
LikeLike
I need your ovcd product.
Please quote price of 5kw and 10 kilowatt model
LikeLike
you can buy it online from https://www.instamojo.com/micross/
LikeLike
is this product suitable to carry 30 amps ac current what is price of the above . low / high voltage setting range
LikeLike
yes, it is . multiply Amperes by voltage 230V . so in your case 30 A x 230V = 6900VA.
we have 10kVA model to suit your requirement .
Visit our online store https://www.instamojo.com/micross/ to view information on pricing or to buy one
LikeLike
I want to buy for my home? Would it run my all home appliances at a time, eg.. Fridge, tv, gizer, kitchen chimney, water pump, owashing maching etc through this OVCD?
LikeLike
Please contact us on 9769996205
LikeLike
How much Price of this product
LikeLike
Please contact us on 9769996205
LikeLike
Dear sir
Can we connect a single piece ovcd for the entire house if yes then what is the cost
LikeLike
Please email us on info@microsystemservices.com
LikeLike
Pls how can i reduce the under voltage from 165v to 150v
LikeLike
yes it is . you can send the unit back to us
email us at production@microsystemservices.com
LikeLike
I have a lift on my premises. Kindly suggest a protection system from surges (lightning surges and line surges) . Do we need to install at both places, near the main DB and near the lift DB?
LikeLike
I will be making a new post on same issue
LikeLike